Safety Research & Strategies Sues U.S. DOT in (Another) FOIA Dispute

Safety Research & Strategies, an automobile and product safety research and consulting firm, today filed its fourth Freedom of Information lawsuit against the U.S. Department of Transportation, alleging that it has improperly held documents regarding Early Warning Reports.

The lawsuit emanates from two instances in which manufacturers allegedly did not report serious injury claims against them to NHTSA, as required under the Transportation Recall Enhancement Accountability and Documentation (TREAD) Act’s Early Warning Reports (EWR) provision. One crash occurred in April 2009, involving a tire tread separation which resulted in an occupant sustaining a serious closed head injury. The second crash occurred in June 2010, involving the apparent failure of Harmony Lite Rider child restraint, which caused severe injuries to two young children.

“EWR data is supposed to alert the agency investigators to defect trends,” says SRS President Sean E. Kane. “But if manufacturers don’t report complete and accurate information, the system doesn’t work.”

Harmony, which manufactured the child safety seat and Nankang, the Taiwanese tire manufacturer, and Tireco, the tire importer, were notified of these claims via civil lawsuits in August 2010 and November 2011, respectively. Neither, however, showed up in a search of the manufacturer’s quarterly reports to NHTSA.

In March, SRS informed the director of the Office of Defects Investigation Frank Borris, and NHTSA’s Senior Associate Administrator for Safety, Daniel C. Smith, of these apparent omissions. The memo requested confirmation that these claims should have been submitted to the agency via a quarterly EWR submission, and “what actions the agency plans to take.” After receiving no reply, SRS submitted, in May, a Freedom of Information Act request, seeking any documentation that NHTSA followed up with Harmony, Nankang or Tireco, as well, as the agency’s policies and procedures around EWR, and a manufacturer’s failure to submit a reportable incident.  

Toyota’s Motion is Extra-Judicialious!

Two judges have turned down Toyota’s request to bar Plaintiffs from speaking to the press about their unintended acceleration cases.

Guadaloupe Alberto of Flint, Michigan died in April 2008, when her 2005 Camry accelerated out of control, left the roadway and struck a tree. Alberto was known as a cautious driver; the 2005 Camry is known as one Toyota’s most problematic UA vehicles. Alberto v. Toyota is now set for trial in February 2014.

In September 2007, Jean Bookout and her friend and passenger Barbara Schwarz were exiting Interstate Highway 69 in Oklahoma in a 2005 Camry. As she sped down the ramp, Bookout realized that she could not stop her car. She pulled the parking brake, leaving a 100-foot skid mark from right rear tire, and a 50-foot skid mark from the left. The Camry, however, continued speeding down the ramp, across the road at the bottom, and finally came to rest with its nose in an embankment. Schwarz died of her injuries; Bookout spent two months recovering from head and back injuries. Bookout v. Toyota is also soon headed for trial in the District Court of Oklahoma County, Oklahoma.

On Sept. 4, Toyota moved for a gag order in Alberto, to stop the family and its attorneys, including West Virginia lawyers Benjamin Baily and Edgar “Hike” Heiskell III, from talking to the press.

“Defendants believe that statements to the media and the release of witness deposition testimony will have a substantial likelihood of materially prejudicing the proceedings and jury selection as prospective jurors should consider only the evidence present at the trial,” the automaker argued.

Time to Call BS: Why Safety Groups Sued DOT Over Backover Rule Delay

Last week, a consortium of safety groups and advocates decided it had had enough of the delay tactics in publishing a final rule establishing a rear visibility standard and sued the Department of Transportation.

“We are going through the motions of trying to put pressure on the system to cough out the rule,” says attorney Henry Jasny of Advocates for Highway and Auto Safety. “We’ve got a new Secretary of Transportation, and to help him along we figured we’d get the court involved.”

The petitioners before the U.S. Court Of Appeals’ Second Circuit in New York includes three organizations – KidsAndCars, Advocates for Highway and Auto Safety and Consumers Union – and two New York residents who have backed over their children – Sue Auriemma of Manhasset and pediatrician Greg Gulbransen of Syosset. The 2008 Cameron Gulbransen Kids Transportation Safety Act was named for two-year old Cameron Gulbransen, who was killed when his father accidentally backed over him in the family’s driveway. It required the agency to issue a Final Rule amending Federal Motor Vehicle Safety Standard (FMVSS) 111, the rearview mirror standard, to, for the first time, define what a driver sees in the rear when backing up to detect pedestrians immediately behind his or her vehicle. The law forced the agency to address a significant design flaw – especially in SUVs – of expanded blind zones caused by the vehicle’s height and bulk. Dramatic pictures from KidsAndCars shows as many as 62 children arrayed directly behind an SUV that would be unseen by driver checking the rearview mirrors.

[flashvideo file=video/KAC_62Children30.flv image="video/KAC_62Children30_Preview.jpg" /]

The original statutory deadline was February 28, 2011, but the Final Rule has been delayed four times, and now is on track to be completed four years after the deadline. In one of his last acts, former Secretary of Transportation Ray LaHood sent another letter to Congress delaying the issuance of a Final Rule until January 2015. (The new Secretary of Transportation, former Charlotte, North Carolina Mayor Anthony Foxx, started in July.)

Crazy Ray’s Give Away!

T-Minus three and counting before the rollercoaster ride that is the tenure of Department of Transportation Secretary Ray LaHood careens to a stop. But, not before he did one last handstand for the crowd.

With the National Highway Traffic Safety Administration and Chrysler on a collision course over a recall to remedy the aft-of-the axle fuel tank design of the early model Jeep Grand Cherokees and some Jeep Liberty SUVs that is prone to explode into flames in a rear impact, LaHood, donned his super-hero tights and flew to what he imagined to be the rescue.

Now, most backroom deals attempt to stay on the QT. But, Ray LaHood, never one to miss an opportunity to pat himself on the back, could not be silent. He gave David Shepardson of The Detroit News the scoop: Six days before Chrysler would have to formally respond to NHTSA’s request that Chrysler recall 2.7 million 1994-2004 Jeep Grand Cherokees and 2002-2007 Jeep Liberty SUVs, Ray got Chrysler Group CEO Sergio Marchionne on the blower and said something like, “Look here, old man, no one takes safety more seriously than Ray LaHood and we’ve got to figure this Jeep thing out!”

Chrysler had heretofore demonstrated a very public unwillingness to recall those Jeep models, based on a shaky statistical analysis that threw every model on the wall it could think of to make the pre-2005 Jeep Grand Cherokee (before they moved the tank) look not-so-horrible. On June 9, LaHood drove from his home in Peoria, Ill; Marchionne flew in from Italy and David Strickland, ever playing Jimmy Olsen to LaHood’s Superman, flew from D.C. to Chicago. The trio converged at the Federal Aviation Administration building at O’Hare Airport for a “tough, hour-long ‘frank’ meeting,” according to Shepardson’s story.

As reported by Shepardson, Marchionne dispatched some engineers the next day to D.C. to come up with “the outlines” of a remedy with NHTSA. In public, the confrontation appeared to build, encouraged by business and auto journalists who seemed excited by the prospect of Chrysler sticking its finger in the government’s eye. Just as the showdown drew nigh, the automaker announced that it would implement a “voluntary campaign” to add trailer hitches to some older models.

Ray could not contain his enthusiasm for the remedy:

The Safety Record Special Report: How Consumer’s Union Shocking Child Seat Tests Forced the Recall of the Evenflo Discovery

Editor’s note: The Safety Record spent more than a year seeking the documents related to Recall 08C002 involving Evenflo Discovery child restraint.  The Safety Record undertook this project because the defect was serious, resulting in a recall of more than 1 million seats. Yet, much the public record explaining how this recall came about was missing, and, the National Highway Traffic Safety Administration was not forthright in its actions or in its public statements in February 2008. The Safety Record is committed to ensuring that the public record is complete and to bringing transparency to NHTSA’s important regulatory and investigative activities in the interest of government accountability. Documents obtained following the successful settlement of Safety Research & Strategies litigation against NHTSA show that the Evenflo recall was the result of secret investigations and behind-the-scenes exchanges between the agency and Evenflo. This Special Report, in part, is based on these records.  

On September 19, 2005, Isaac Neal Eslinger died of his injuries in a rollover crash that occurred the day before. He was seven months old. His mother Debra was at the wheel of the family’s 1996 Isuzu Oasis van, travelling north on Highway 6 towards Mandan, North Dakota. According to the police report of the crash, the last thing Debra Eslinger remembered was glancing back at her daughter, before realizing that she had swerved onto the shoulder of the other side of the road. Debra tried to correct her steering, but lost control of the van. It rolled over and came to rest in a ditch on the east side of the highway.

Debra, who was wearing her seatbelt, and her three-year-old daughter, secured in a child safety seat, survived the crash without any injuries. The Evenflo Discovery infant seat holding Isaac, however, detached from its base in the crash. Isaac, still strapped in the seat, was pitched out of the van. He died of a skull fracture and head injury.

Isaac’s father, Neal Eslinger, a chiropractor in Bismarck, paid tribute to his only son on a blog he writes, called My Living Strength:

“Isaac has a spirit presence that warmed all hearts. He was a “master of smiling” as he displayed his prominent dimples, twinkling eyes and his unique laughs, giggles and squeaks. The mere glimpse of his mother or sound of her voice would bring a smile and a laugh that truly was an honor to witness. …Isaac was a gift from God and he always was and always will be “Our Little Angel.” Words cannot express the blessings he brought into our lives.”

Three weeks after the crash, on Oct. 7, 2005, Isaac Eslinger’s death in an Evenflo Discovery infant seat was reported to the National Highway Traffic Safety Administration. Fifteen months later, NHTSA’s Office of Defects Investigation came looking for the crash report.

January 2007 would turn out to be a turning point for the popular infant carrier combination car seat. A controversial Consumer Reports story claimed that sled-tests showed that some models of the Discovery had a tendency to separate from its base under the stress of crash forces. This wasn’t actually news. A spate of infant deaths and injuries linked to base separations had initiated a low-level NHTSA investigation in 2004. But that probe was closed four months later with no defect finding.

NHTSA and Evenflo swiftly dispatched the Consumer Reports story by pointing out that its side-impact sled tests were actually conducted at a much higher rate of speed than the story claimed. Within weeks, Consumers Union, publisher of Consumer Reports, printed a retraction, withdrew the story and apologized to its readers. But one year later, NHTSA and Evenflo announced that the juvenile products manufacturing firm was recalling 1.1 million Discovery infant carriers because testing by both parties showed that it could separate from its base in a side impact.

In the three-and-a-half year gap between the closing of the first investigation and the recall of the Discovery infant carrier were two secret NHTSA defects investigations into the infant carrier’s propensity for seat base separations, the discrediting of a consumer advocacy organization that attempted to raise the bar on child restraint safety, and more child injuries and deaths in crashes that resulted in base separations.

The recall was five years ago, but questions about its origins linger. Save a flurry of stories published about CU’s testing mistake and retraction, and fewer when the recall was announced a year later, the record surrounding this child safety defect has remained hidden from public view. Increasingly, this appears to be by design. NHTSA frequently hides the extent of its investigative activities and its negotiations with industry. If no formal Preliminary Evaluation or Engineering Analysis is opened, the public record is never established. This secrecy has been the subject of criticism by safety advocates, who say that it allows the agency to avoid accountability, and by the Department of Transportation’s Office of Inspector General. In an October 2011 audit, the OIG criticized the Office of Defects lack of documentation and transparency:

“Without comprehensive documentation of pre-investigation activities, ODI’s decisions are open to interpretation and questions after the fact, potentially undermining public confidence in its actions.” Noting NHTSA’s failure to document meetings with manufacturers, OIG recommended “a complete and transparent record system with documented support for decisions that significantly affect its investigations.”

In November 2011, Safety Research & Strategies filed a Freedom of Information Request for the communications between NHTSA and Evenflo surrounding February 2008 recall. When NHTSA responded that it had no such documents, SRS appealed – arguing that the simultaneous press releases issued by NHTSA and Evenflo showed that each entity knew about the other’s test results on the Discovery – evidence of communication between the two. In April, after NHTSA did not respond to SRS’s appeal, the company filed a civil lawsuit in U.S. District Court to obtain the documents. In February, SRS and the Department of Transportation settled the lawsuit, after NHTSA released all of the documents it said were in its possession. The Department of Transportation paid SRS’s costs and legal fees of $14,281. 

Top Ten Reasons We’ll Miss Ray LaHood

We knew as far back as October 2011 that Ray LaHood was only going to be a one-term Secretary of Department of Transportation. And yesterday, he announced his imminent departure. Ray LaHood is a brilliant politician – all confidence and certainty, a loud combination of consumer-tough-guy-bluster-and-chamber-of-commerce-boosterism. He wasn’t afraid to take public stands no matter how misguided – we’ll give him that.

Admittedly, we are not close observers of the totality of LaHood’s activities. But we have traced LaHood’s fingerprints on technologically-rooted safety problems, and they have been a source of grim amusement. Without further introduction, we give you: SRS’s Top Ten Reasons We’ll Miss Ray LaHood

1. Top Illeist in the Obama Administration

An illeist is someone who refers to him or herself in the third person.

Like Ray telling PBS interviewer Gwen Ifill: “I think that Mr. Toyoda wouldn't be here today if it weren't for Ray LaHood calling him and our people going to Japan and telling them this is serious.” Or, Ray telling NPR talk show host Diane Rehm “Diane, you and I have had discussions about airline safety before on your show and you know that nobody cares as much about safety as Ray LaHood.”

Why does a person talk about himself that way? If you are under three years old, pediatricians considered a linguistic quirk of toddlerhood. If you are over thirty, psychologists consider it a narcissistic personality trait.

Move over, famous illeists, Richard Nixon, Herman Cain, Jimmy in Seinfeld and every professional athlete – and make room on the bench for Mister Ray LaHood. 

2. Outstanding Projectionist

When Ray LaHood is annoyed – hoo-boy, don’t you know it. In February 2011, the National Highway Traffic Safety Administration released two reports purporting to resolve the question of whether electronics could be the source of Toyota Unintended Acceleration complaints. The agency kept a very tight lid on their release, handing them out to select journalists only an hour before the press conference. Both reports were lengthy, dense and highly redacted. But, writers gotta write and deadlines don’t move. Then Ray made the news show rounds complaining that the media hadn’t read the report. We read the reports, and re-read them, and we know, after listening to Ray’s characterization of its contents, that Ray did not read the reports, either.

Maybe in retirement, he’ll get around to it.

3. Undeterred by Facts

“The jury is back,” he announced. “The verdict is in. There is no electronic-based cause for unintended high-speed acceleration in Toyotas. Period.”

This pronouncement, more than any Ray LaHood made in his four-year tenure, really fried our butts.

The twin reports, Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems and Technical Support to the National Highway Traffic Safety Administration on the Reported Toyota Motor Corporation Unintended Acceleration Investigation, actually said:

“Due to system complexity which will be described and the many possible electronic hardware and software systems interactions, it is not realistic to attempt to ‘prove’ that the ETCS-i cannot cause UAs. Today’s vehicles are sufficiently complex that no reasonable amount of analysis or testing can prove electronics and software have no errors. Therefore, absence of proof that the ETCS-i has caused a UA does not vindicate the system.”

The latter report, by the NASA Engineering Safety Center showed that there were several scenarios in which engine speed can be increased, RPMs can surge, and the throttle can be opened to various degrees in contradiction to the driver’s command, and not set a Diagnostic Trouble Code (DTC). Among those causes of electronic malfunction in some Toyota vehicles the investigators found were tin whiskers in the Accelerator Pedal Position Sensor (APPS) of potentiometer-type pedals. The NESC and NHTSA teams did not engage independent engineers with expertise in vehicle engine management design, validation and testing to assist them, they allowed Toyota and Exponent to guide this research. To boot, the lauded space agency never examined components from any vehicles that experienced high-speed UA events – the very focus of the lengthy technical tome. 

LaHood’s willingness to elide the facts in favor of a sound-bite that puts the matter to rest hurt every Toyota owner.

 4. Effective Policymaker

Everybody Loves Raymond

The Boeing Dreamliner is a dream – as long as your dream includes a three-year wait for your order due to production problems, or engine failures or electrical system headaches. All these and more have plagued the 787 jet airliner in the last several years. The latest bad news: today Japan Airlines and All Nippon Airways grounded their 24-jet Dreamliner fleets at least until tomorrow, after a battery warning light and burning smell in the cockpit and cabin forced a landing and evacuation. This mishap follows a January 7 cabin fire aboard a Japan Airlines Dreamliner caused by an overheated battery, a cracked cockpit window, fuel leaks, an oil leak and brake issues.

The Federal Aviation Administration had announced that it had initiated a nose-to-tail review of the jet’s design, manufacture and assembly, which Boeing had pitched as a fuel-efficient aircraft constructed of lighter weight composite materials. No worries, though. According to our Chief Transportation Salesman Ray LaHood, it’s all good.

“I believe this plane is safe and I would have absolutely no reservations of boarding one of these planes and taking a flight,” LaHood asserted at a press conference.

Pages

Categories

Archive Dates

Follow us on Twitter

Categories

Archive Dates

Follow us on Twitter